Rolls Royce AE1107C jet engines are wearing out ahead of schedule

Rolls Royce AE1107C jet engines are wearing out ahead of schedule (NSI News Source Info) September 19, 2008: The Rolls Royce AE1107C jet engines (that drive the propellers) in the U.S. Marine Corps new tilt rotor V-22 aircraft, are wearing out ahead of schedule. That is endangering a unique maintenance program. Overall, V-22 engines last nearly 500 hours (and some have gone over 600 hours), but in Iraq, the average is not quite 400 hours. This is particularly bad news for Rolls Royce, which sold the Department of Defense a "power by the hour" maintenance agreement. The deal is what the name implies. The user pays Rolls Royce a variable amount for repairs and replacement of the engines, depending on how many hours the engine is used. This approach has become quite popular, and successful, for commercial, and now military, engines (and other equipment as well). This system gives the maintenance supplier (often the manufacturer) a financial incentive to build the gear to last, and to keep running without untimely failures. This works fine for equipment that is used in known conditions. The peculiar sand and dust in Iraq, in addition to the high temperatures, proved to be so extreme, that they wore down the AE1107C engines faster than Rolls Royce had anticipated. The maintenance deal is being renegotiated. If the "power by the hour" deal for the V-22 does not work, the V-22 will be more expensive to operate, and will be down for maintenance more often. The MV-22s used by the marines can carry 24 troops 700 kilometers (vertical take-off on a ship, level flight, landing, and return) at 390 kilometers an hour. The V-22 is replacing the CH-46E helicopter, which can carry 12 troops 350 kilometers at a speed of 135 kilometers an hour. The V-22 can carry a 10,000-pound external sling load 135 kilometers, while the CH-46E can carry 3,000 pounds only 90 kilometers. The marines began using the MV-22 in Iraq late last year, and have been satisfied with the results. However, it was expected that there might be problems with engine durability. Every other vehicle that uses a gas turbine engine in Iraq (from M-1 tanks to C-17 jet transports) have reported increased wear on their engines because of the copious and continuous dust and sand in Iraq. For the V-22, another problem is that even frequent inspections won't always catch an engine that's about to die from too much dust and sand. Several MV-22s in western Iraq (Anbar province, where marine MV-22s were operating) have experienced engine failures. There have been no crashes, but there have been emergency landings (followed by quick engine changes so the $70 million, 20 ton aircraft could get home under its own power). The Rolls Royce T-406 engines weigh about a ton each, and put out 6,000 horsepower. Marine maintenance crews are trained to put a spare engine inside a V-22, along with needed tools, fly out to where another V-22 has made an emergency landing, do the engine change quickly, and get back to base in one piece.